Dixon ZTR 5023 Operator's Manual download pdf (Page 55)

1. ENGINE WONT TURN OVER

Mower blades engaged- - - - - - - - - - - - - - - - - - - - - - -disengage blades

Drive not in neutral - - - - - - -move control levers to neutral OUT

Circuit breaker trips- - - - - - - - - - - - - - - - - - - - - - - - - - -- - - - - reset breaker

Dead battery- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - charge or replace

Solenoid- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -consult dealer

Ignition switch- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -consult dealer

Starter- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -consult dealer

Parking brake not on- - - - - - - - - - - - - - - - - - - - -engage parking brake

2. ENGINE WILL TURN OVER BUT WONT START

No fuel- - - - - - - - - - - - - - - refuel and/or clean or replace fuel filters

3. HARD TO START ENGINE

Fuel line clogged- - - - - - - - - - - - - clean fuel line and check fuel filter

Faulty fuel pump- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -consult dealer

4. ENGINE STARTS BUT CUTS OUT

Water in fuel- - - - - - - - - - - - - - - -drain old fuel-replace with new fuel

Clogged fuel line- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -check fuel filter

Fuel tank vent plugged- - - - - - - - - - - - - - - - - - - - - - - - - - - -clean fuel vent

Faulty fuel pump- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - check vent

5. ENGINE OVERHEATED

Air intake screen or fins clogged- - - - - -clean intake screen and fins

Oil level too low or too high- - - - - - - - - - - - - - - - - - - - - - - - - adjust oil level

Running engine too slow - - - - - - - - - - - - - - - - - - - - - - - -run engine faster

TROUBLESHOOTING

1 2 ... 50 51 52 53 54 55 56 57 58 59 60

No comments

Dixon ZTR 5023 Operator's Manual Page 55